Ford Focus 1.6 Tdci Hdi P0405 EGR Valve Replacement Fitting - YouTube. © 2023 Google LLC. how to replace EGR valve on ford focus 1.6 dieselexhaust gas recirculation valve fitting. Focus 2.0L: Ford Focus 2.0 TDCi Hatchback; Ford Focus 2.0 TDCi ST Hatchback; Ford Focus 2.0 TDCi Saloon; Ford Focus Turnier 2.0 TDCi Estate; Ford Focus Turnier 2.0 TDCi ST Estate; Kuga II 2.0L: Ford Kuga 2.0 TDCi 4X4 SUV; Ford Kuga 2.0 TDCi SUV; 2.0: 2014-2018: SKU: M002-086; OEMS: FORD FINIS 1902014, FORD 8C11-9T540-BA; Ex Tax: £113.98 . Inc Hi Ok if the EGR cooler was leaking then there would be a drop in the coolant level Obvious I cannot see how thick etc the smoke/smog is It sounds like overfuelling due to the symptoms of diesel knock etc It would be worth removing the leak off pipes to clarify if this return valve could be the problems this forces fuel back to the injectors instead of smoothly outthe return to pump Also these P042F - EGR valve actuator A- actuator stuck closed Ford Model: Focus 2 1.6 TDCI 110 HP Ford Year: 2011 UK/Ireland Location: Other/NonUK Share; Jul 1. 6. Aug 31. 4. Cleaning clogged DPF on Ford Focus II 1.6 TDCI - FORScan forum Valeo EGR Valve 700444 is only suitable for Ford, Mazda, Mini and Volvo How to open an EGR valve for cleaning and putting it back together. This is an EGR valve for Peugeot, Citroen, Ford, Volvo, etc., with the 1.6HDi engine. Cle 4F4x1v9. Except for one code, P042f - EGR valve stuck closed. I cleaned the EGR and inlet manifold. But even after cleaning (and clearing DTCs) the EGR flags up the same fault code. Van occasionally feels very low on power at low revs, to the extent that it will barely accelerate in 1st gear, until revs are up to close to 2k. Step 1: Locate the EGR temperature sensor. The EGR temperature sensor is usually mounted in the exhaust manifold or mounted near the EGR valve. Part 2 of 3: Remove the EGR temperature sensor. Step 1: Disconnect the negative battery cable. Disconnect the negative battery cable and set it aside. Step 2: Remove the electrical connector. Remove the Hi all, I've been having DPF problems with my 1.6 TDCI focus (2010, 76K miles), and need a bit of advice on decisions going forward. I haven't found one post that really explores different DPF options together clearly, so hopefully this will prove useful for others. Symptoms and diagnosis: - Car' my Focus '54plate 1.8 TDCI (last of line previous gen)had a similar problem, it was ok if i used half throttle or 3/4 throttle but full throttle resulted in violent judder at any speed and no Ford Focus 1.6 TDCi Mk2 - Limp Mode, split in rubber hose / connector. Hi, I'll try and keep this short :-) My Ford Focus 1.6 TDCi Mk2 keeps going in to limp home mode but showing no errors and appears to be OK after turning off and on the engine - but under load (e.g. up a hill) will go back in to limp home mode and kick out a cloud of smoke.

ford focus 1.6 tdci egr valve symptoms